Effects of Storage Temperature and Rice Moisture Content on Quality of Rice in Carbon Dioxide Atmosphere Storage

doi:10.3969/j.issn.1006-8082.2024.06.010

China Rice ›› 2024, Vol. 30 ›› Issue (6): 60-65.DOI: 10.3969/j.issn.1006-8082.2024.06.010

• Special Thesis & Basic Research • Previous Articles Next Articles

Effects of Storage Temperature and Rice Moisture Content on Quality of Rice in Carbon Dioxide Atmosphere Storage

YE Jialin¹^,⁴, DU Jinglin², WU Guangyue³, HU Jiahan¹, WANG Aoxi¹, LV Zhaoying¹, HU Hao¹^,^*()

¹College of Food and Health, Zhejiang Agriculture and Forestry University, Hangzhou 311300, China
²Zhejiang Food Security Service Center, Hangzhou 311258, China
³Beijing Dongfu Jiuheng Instrument Technology Co., Ltd, Beijing 100037, China
⁴Jinhua Grain Storage Co., Ltd., Jinhua, Zhejiang 321000, China

Received:2023-08-17 Online:2024-11-20 Published:2024-11-19
Contact: HU Hao

温度及水分含量对二氧化碳气调储藏稻谷品质的影响

叶佳琳¹^,⁴, 杜京霖², 吴光玥³, 胡家涵¹, 王澳希¹, 吕昭颖¹, 胡浩¹^,^*()

¹浙江农林大学食品与健康学院，杭州 311300
²浙江省粮油产品质量检验中心，杭州 311258
³北京东孚久恒仪器技术有限公司，北京 100037
⁴金华市粮食收储有限公司，浙江金华 321000

通讯作者: 胡浩
基金资助:
宁波市科技计划项目(2022Z182);国家级大学生创新创业训练计划项目(202110341053)

Abstract

Abstract:

The quality of rice will deteriorate during storage due to the influence of temperature, humidity, environmental gas composition and other factors. As one of the important grain storage methods, carbon dioxide atmosphere storage is rarely studied. Under the conditions of carbon dioxide controlled atmosphere storage, four temperature and humidity treatments （low temperature and low moisture: the storage temperature is 20 ℃, and the moisture content of rice is 12.5%; low temperature and high moisture: the storage temperature is 20 ℃, and the moisture content of rice is 15.5%; high temperature and low moisture: the storage temperature is 37 ℃, and the moisture content of rice is 12.5%; high temperature and high moisture: the storage temperature is 37 ℃, and the moisture content of rice is 15.5%）were set up, and after 6 months of storage, a comparative study was conducted on the physical and chemical indexes and food quality of the tested varieties (Yongyou 1540 and Xiushui 134). The results showed that compared to the rice stored just after being stored, under low temperature and low moisture treatment for 6 months, the conductivity of the rice increased by 34.96%, the fatty acid value increased by 10.24 mg/100 g, the malondialdehyde content increased by 4.38 mg/kg, the germination rate, the roughness rate and the whole rice rate decreased by 5.66, 3.76 and 12.05 percentage points respectively, and the yellow grain rate increased by 0.07 percentage points, was the best performance in all four treatments. It can be seen that low temperature and low moisture is more suitable for storing rice, which can effectively delay the aging and deterioration of rice, and preserve the nutritional value of rice

Key words: rice, storage temperature, moisture, quality

摘要：

受温湿度、环境气体成分等因素影响，稻谷在储藏过程中会发生品质劣变。二氧化碳气调储藏作为重要的谷物储藏方式之一，目前相关研究较少。本试验设置4个处理（低温低水分：储藏温度20 ℃，稻谷水分含量12.5%；低温高水分：储藏温度20 ℃，稻谷水分含量15.5%；高温低水分：储藏温度37 ℃，稻谷水分含量12.5%和高温高水分：储藏温度37 ℃，稻谷水分含量15.5%），二氧化碳气调储藏6个月后对参试品种（甬优1540和秀水134）稻谷理化指标和食用品质进行比较研究。结果表明，相比入库储藏时，低温低水分处理储藏6个月后的稻谷电导率增34.96%，脂肪酸值增10.24 mg/100 g，丙二醛含量增4.38 mg/kg，发芽率、糙米率和整精米率分别降低5.66个、3.76个和12.05个百分点，黄粒米率增加0.07%，在4个处理中均表现最好。可见，低温低水分储藏更加适合稻谷，能够有效延缓稻谷陈化劣变、延长稻谷储藏时间、保存稻谷营养价值。

关键词: 稻谷, 储藏温度, 水分, 品质

CLC Number:

S511.093

YE Jialin, DU Jinglin, WU Guangyue, HU Jiahan, WANG Aoxi, LV Zhaoying, HU Hao. Effects of Storage Temperature and Rice Moisture Content on Quality of Rice in Carbon Dioxide Atmosphere Storage[J]. China Rice, 2024, 30(6): 60-65.

叶佳琳, 杜京霖, 吴光玥, 胡家涵, 王澳希, 吕昭颖, 胡浩. 温度及水分含量对二氧化碳气调储藏稻谷品质的影响[J]. 中国稻米, 2024, 30(6): 60-65.

Figures/Tables 9

References 17

[1]	徐春春, 纪龙, 陈中督, 等. 2023年我国水稻产业形势分析及2024年展望[J]. 中国稻米, 2024, 30(2):1-4.
[2]	张从超, 杨波, 杨光, 等. 大米加速陈化的研究进展[J]. 食品与发酵工业, 2022: 1-8.
[3]	刘旭光, 朱华锦, 洪文奎, 等. 二氧化碳气调储粮新工艺试验[J]. 粮食储藏, 2019, 48(3): 6-9.
[4]	司建中. 氮气气调储粮与二氧化碳储粮对比分析[J]. 粮油仓储科技通讯, 2011, 27(6):40-42.
[5]	龚志刚, 刘旭光, 严晓平, 等. 二氧化碳气调对储粮害虫及虫卵防治效果研究[J]. 粮食储藏, 2023, 52(3):35-38.
[6]	王若兰, 宋永令, 付鹏程. 中国稻谷储藏技术及装备的现状及发展趋势[J]. 中国稻米, 2021, 27(4):66-70.
[7]	QU C L, LI W H, YANG Q K, et al. Metabolic mechanism of nitrogen modified atmosphere storage on delaying quality deterioration of rice grains[J]. Food Chemistry X, 2022, 16: 100 519.
[8]	高一程. 氮气和二氧化碳气体气调对赤拟谷盗的熏蒸处理技术研究[D]. 泰安: 山东农业大学, 2019.
[9]	MITRA A, LI Y F, KLAMPFL T G, et al. Inactivation of surface-borne microorganisms and increased germination of seed specimen by cold atmospheric plasma[J]. Food and Bioprocess Technology, 2014, 7(3): 645-653.
[10]	牛浩. 烟叶能量代谢和膜脂过氧化与颜色变化的关系研究[D]. 郑州: 河南农业大学, 2022.
[11]	WANG T, SHE N N, WANG M N, et al. Changes in physicochemical properties and qualities of red brown rice at different storage temperatures[J]. Foods, 2021, 10(11): 2 658.
[12]	刘剑涛, 张莹莹, 罗昊文, 等. 不同储藏温度对香稻谷品质和香气的影响[J]. 粮食与油脂, 2022, 35(9):100-103.
[13]	赵东霞. 稻谷、糙米和稻壳脂肪酸含量及相关性研究[J]. 中国稻米, 2018, 24(4):55-56.
[14]	姚亚静, 芦熹坤, 李建颖, 等. 糙米储藏中品质特性变化及调控研究进展[J]. 食品研究与开发, 2021, 42(15):204-209.
[15]	HUANG Y T, WU W, ZOU W X, et al. Drying temperature affects rice seed vigor via gibberellin, abscisic acid, and antioxidant enzyme metabolism[J]. Journal of Zhejiang University-SCIENCE B, 2020, 21(10): 796-811.
[16]	赵延成, 周长华. 提高玉米种子发芽率的有效措施[J]. 特种经济动植物, 2022, 25(11):122-123.
[17]	万忠民, 张崇彬, 邓铭杰, 等. 基于电子鼻和GC-MS对优质稻谷挥发性成分差异性分析[J]. 中国粮油学报, 2022, 37(8):261-271.

Effects of Storage Temperature and Rice Moisture Content on Quality of Rice in Carbon Dioxide Atmosphere Storage

温度及水分含量对二氧化碳气调储藏稻谷品质的影响

RichHTML

PDF

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 9

References 17

Related Articles 15

Recommended Articles

Metrics

[1]	DAI Shuaijun, ZHANG Yunbo, HUANG Liying. Research Progress on the Early Vigor of Cereal Crop [J]. China Rice, 2025, 31(1): 1-10.
[2]	WEN Ya, GU Jiayi, WANG Chaorui, ZHANG Ying, XIAO Zhilin, ZHANG Hao. Research Progress on Nitrogen Fertilizer Management Techniques for High Yield and Emission Reduction in Rice Production and Their Impacts on Greenhouse Gas Emissions from Paddy Fields [J]. China Rice, 2025, 31(1): 11-17.
[3]	HUANG Nanxun, ZHANG Minqiang, YE Qingsheng, ZHANG Congkun, LI Jianxiong, WANG Xinyu, FU Youqiang, LIANG Kaiming. Effects of Different Cultivation Techniques and Varieties on Grain Yield, Fertilizer Utilization and Indirect Carbon Footprint of Indica Rice in South China [J]. China Rice, 2025, 31(1): 18-26,34.
[4]	LIU Qing, SUN Luhong, GAO Shiwei, LIU Yuqiang, CHANG Huilin, MA Cheng, WANG Jingze, WANG Cuiling, NIE Shoujun. Effects of Salicylic Acid on Growth and Physiological Characteristics in Different Drought Tolerance Rice Varieties under Drought Stress [J]. China Rice, 2025, 31(1): 27-34.
[5]	LI Hu, WU Zishuai, LIU Guanglin, CHEN Chuanhua, LUO Qunchang, ZHU Qinan. Analysis of Variation Types of BADH2 Aroma Genes and Detection of Rice Blast Resistance Genes in 80 Aromatic Rice Materials [J]. China Rice, 2025, 31(1): 35-43,53.
[6]	MAO Xiaohong, LI Yiyun, FU Linlin. Study on the Characteristics of Grain Production and the Countermeasures of Productivity Improvement in Zhejiang Province [J]. China Rice, 2025, 31(1): 44-53.
[7]	YU Yanfeng, YUAN Tingting, YU Yongqi, SUN Mingzhu. Situation and High-quality Development Strategies of Jiangxi’s Grain Industry [J]. China Rice, 2025, 31(1): 54-60.
[8]	DUAN Junzhi, YAN Zhaoling, QI Hongzhi, ZHANG Huifang, CHEN Haiyan, YANG Cuiping, WANG Nan, ZHUO Wenfei. Progress on Application of WRKY Transcription Factor in Rice Stress Tolerance Genetic Engineering [J]. China Rice, 2025, 31(1): 61-67,73.
[9]	LIU Youhong, TANG Ao, DONG Wenjun, MENG Ying, ZHANG Xijuan, LIU Kai, LENG Chunxu, SHANG Quanyu, LAI Yongcai. Evolution Rule of Major Agronomic Traits of Heilongjiang Japonica Rice at Different Breeding Stages [J]. China Rice, 2025, 31(1): 68-73.
[10]	WANG Ying, MA Jiansen, WANG Fang, LIU Ruliang, HONG Yu, MAO Xinping. Screening and Evaluation of Nitrogen-Efficient Varieties of Rice in the Yellow Rive Irrigation Area [J]. China Rice, 2025, 31(1): 74-78,83.
[11]	KANG Mintai, DU Xiaojing, ZHANG Yanhong, WEN Xiaorong, TANG Fusen, ZHAO Zhiqiang, YUAN Jie, WANG Fengbin. Principal Component Analysis and Comprehensive Evaluation of Salt Tolerance Related Traits in Japonica Rice in Xinjiang#br# #br# [J]. China Rice, 2025, 31(1): 79-83.
[12]	QIN Yitian, WANG Zaiman, PAN Shenggang, ZHANG Minghua, MO Zhaowen. Comparison of Yield and Grain Quality among Different Fragrant Rice Varieties for Ratooning Rice Planting [J]. China Rice, 2025, 31(1): 84-88,93.
[13]	SHEN Jianghua, XIAO Shan, ZHENG Wei, CHAI Weigang, YAO Hongyan. Study on the Effect of Sex-pheromone-trap Intelligent Monitoring of Chilo suppressalis [J]. China Rice, 2025, 31(1): 89-93.
[14]	WU Huayu, WU Hongmiao, LI Zhong, WU Wenge. Development and Technical Points of the Side Deep Fertilization Technology for Rice Mechanical Transplanting [J]. China Rice, 2025, 31(1): 94-99.
[15]	KANG Hongcan, LI Guosheng, WANG Jinyan, ZHANG Yi, DUAN Haoping, YIN Zhengqin, HE Rongman, CHUAN Xingkuan. Effects of Sowing Date on Fertility Transformation and Self-pollination Rate of Rice Dual-purpose Genic Male Sterile Lines#br# [J]. China Rice, 2025, 31(1): 100-105.